Fan
From VDR Wiki
Contents |
[edit] Introduction
With modern PCs, the fans are the main sound source. Unfortunately, the dissipation loss of high clocked CPUs, graphic cards and other parts forces one to transport the heat out of the case. Nearly all of the output of the power supply is dissipated as heat and has to be taken out of the case, either by air flow or water cooling.
The normal convection of heated air is not enough.
[edit] Heat sources
The hottest parts of a modern computer system
- CPU, dependend of the type it ranges from 8 Watt to 115 Watt(P IV 3.8GHz Prescott)
- power supply, ca. 90..95% efficiency outcomes up to 20 Watt
- DVB card, ca. 8 Watt (Fujitsu-Siemens DVB-C FF)
Other heat dissipating components
- Hard disk
- CD and DVD drive
- Graphic card (up to 50 Watt)
- Mainboard
[edit] The quiet PC
The most efficient abatement of noise is the abandonment of all sound sources. Therefore unnecessary high clock rates should be avoided and low current components should be chosen over normal ones. Only then do low noise fans really make sense.
The loudness of a fan depends on
- Size
- Rotation speed
- Flow rate
- Bearing
- Aerodynamics
- Fixation type (structure-borne sound)
Fans are avaible in the sizes 35, 40 50 60 80 92 and 120 millimeter. Smaller fans must have a higher rotation speed for acceptable flow rates and hence are louder than bigger ones with lower rotation speeds. A good tradeoff are 80mm fans.
Normally fans are driven with 5V to 12V. Higher voltage results in higher rotation speed and more noise. Therefor 12V fans are often driven with only 7V.
When reducing the voltage, check that the fan can really start at the new voltage level.
Also be aware of the fact that the fan now has a lower flow rate with less cooling capacity.
The compromise are fans that are
- temperature controlled
- have good bearings (Ceramics, e.g. Papst)
- 80-120mm in size
- decoupled from the case
[edit] Fan controllers
Fan controller can help adjusting the desired fan speed, but there are also fan controllers with sensors for measuring the hot zones, automatic fan speed adjustment and the stylish look.
| [1] | www.madshrimps.be | Fan controller with three hot zone sensors and automatic fan speed adjustment |
[edit] Common units
- Sone
- Bel
- Phon
- dB(A)
[edit] Fans known to be quiet
- YS-Tech FD1281251B-2A: 17dBa, 40m³/h, 80x80mm, ca. 4Euro at EBay, very low noise at 9V
- Papst 8412 NGL (Hungary): 12dBa, 33m³/h, 80x80mm, ca. 10Euro
- Noiseblocker Silent Fan S1: 11dBa, 38m³/h, 80x80mm, ca. 12Euro
[edit] Useful accessories
- Decoupling set for fans, also offered as "Fan Silencer": ca. 2Euro per 4 apiece
[edit] Links
| [1] | www.silentpcreview.com | Comparison of more than 100 fans at 12V/7V/5V |
